Chrysler Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve)


View 19 Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve) Safety Reports

Chrysler Lebaron 1994
Daimlerchrysler Corporation
Safety incident date:
Oct 08, 1996
Location:
Dyess Afb, TX

pcv valve stopped, then vent tube was blowen in on housing. this resulted in motor oil coming through vent contacting exhaust manifold and starting a fire. please describe details. *ak

Vehicle was on fire. Vehicle Identification Number (VIN):1C3AA3636RF. Vehicle was not using anit-lock brakes. Vehicle was not using Cruise Control.

Chrysler Town And Country 1994
Daimlerchrysler Corporation
Safety incident date:
Dec 02, 1996
Location:
Cleveland, OH

egr valve mounting bracked failed when all four mounting screws holding egr valve rusted, causing vehicle to lose control. *ak

0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):1C4GH54L7RX. Original Owner. Vehicle was purchased on June 01, 1994. Vehicle was using anit-lock brakes.Vehicle was using Cruise Control.Chrysler TOWN AND COUNTRY 1994 Drive type:FWD. Fuel System:N/A. Fuel type: gas. Vehicle Speed: 60 mph.

Chrysler Town And Country 1996
Daimlerchrysler Corporation
Safety incident date:
July 01, 1996
Location:
Los Angeles, CA

the vacuum harness to egr valve failed.

0 person(s) died.Vehicle Identification Number (VIN):1C4GP54LOTB. Original Owner. Vehicle was purchased on Dec 01, 1995. Vehicle was using anit-lock brakes.Vehicle was using Cruise Control.Fuel System:N/A. Fuel type: gas. Chrysler TOWN AND COUNTRY 1996 Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve) Transmission Type: AUTO.

Chrysler Concorde 1993
Daimlerchrysler Corporation
Location:
Ann Arbor, MI

egr valve failed, intake manifold gasket failed.

Vehicle Identification Number (VIN):2C3EL56T2PH. Original Owner. Vehicle was purchased on Apr 01, 1993. Vehicle was not using Cruise Control.

Chrysler Sebring 1998
Daimlerchrysler Corporation
Safety incident date:
Sept 12, 1998
Location:
Newark, OH

due to defective pcv valve vehicle stalled and almost caused an accident. also problems with the boot for the convertible top and ignition. cause unknown. please provide further information. *ak

Original Owner. Vehicle was not using anit-lock brakes. Vehicle was not using Cruise Control.

Chrysler Lhs 1994
Daimlerchrysler Corporation
Safety incident date:
Apr 24, 1997
Location:
San Antoni, TX

plug wires, pcv valve, and hoses failed causing engine to shake at idle and shake upon light acceleration between 35-50 mph. nlm

Vehicle Identification Number (VIN):2C3ED56F2RH. Vehicle was not using Cruise Control.

Chrysler Cirrus 1998
Chrysler Group Llc
Location:
Windermere, FL

egr stuck, causing a sudden loss of power which almost resulted in a rearend crash. dealer was able to duplicate defect, and has replaced egr. *ak

Vehicle Identification Number (VIN):1C3EJ56H6WN. Original Owner. Vehicle was using anit-lock brakes.Vehicle was using Cruise Control.

Chrysler Chrysler 9999
Daimlerchrysler Corporation
Location:
Beaumont, TX

dash light came on indicating that something was malfunctioning on the engine, dealership analyzed system, problem found with egr (exhaust gas recycle) valve, which was working properly but the transducer was malfunctioning, transducer could not be replaced by itself, owner was forced to buy entire kit to correct problem. *cj

Vehicle was not using Cruise Control.

Chrysler Pt Cruiser 2001
Chrysler Group Llc
Safety incident date:
Oct 10, 2003
Location:
South Bend, IN

have a 2001 pt cruiser. poor performance in gas economy, failed catalytic converter now egr valve has failed, i believe it is due to the catalytic converter failure. since chrysler has had other complaints about this issue with the cruisers why have they not been repairing them to the customers satisfaction?*ak

0 person(s) were injured. 0 person(s) died.Mileage was 51000 miles. Original Owner. Vehicle was purchased on June 15, 2001. Vehicle was using anit-lock brakes.Vehicle was using Cruise Control.Vehicle had 4 cylinders. Chrysler PT CRUISER 2001 Drive type:FWD. Fuel System:Fuel injection. Fuel type: gas. Chrysler PT CRUISER 2001 Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve) Transmission Type: AUTO. Vehicle Speed: 50 mph. Dealer's name: Gurley Leep . Dealer's telephone number: 5742714145 . Dealer's city: Mishawaka . Dealer's state code: IN. Dealer's zipcode: 46628 .

Chrysler Town And Country 1997
Daimlerchrysler Corporation
Safety incident date:
Jan 01, 2003
Location:
West Bloomfield, MI

1997 chrysler town and country. the air bag light illuminated, the dealer stated the clock spring shorted out internally, however the consumer received a notice in the mail, regarding the clock spring and that it would be replaced regardless of mileage. the check engine light illuminated, the dealer replaced the egr valve. *jb

Vehicle Identification Number (VIN):1C4GP64L6VB. Vehicle was not using anit-lock brakes. Vehicle was not using Cruise Control. Fuel type: gas.

Chrysler Pacifica 2004
Daimlerchrysler Corporation
Safety incident date:
Dec 18, 2004
Location:
Goose Creek, SC

i purchased my 2004 chrysler pacifica approximately one year ago. i currently have over 18,000 miles on the vehicle, which has been plagued with problems. my engine light has stayed on almost continuously since july 2004. the service department can't seem to repair this problem. the egr sensor failed on a recent trip and my vehicle began to lose power and make loud noises that could be heard by other drivers on the road. the ball joints have had to be replaced. the axle seals have been replaced and now an axle has to the replaced. either my vehicle is the only lemon in the orchard or chrysler has a serious problem with the pacifica.*ak

Vehicle Identification Number (VIN):2C8GF68454R. Original Owner. Vehicle was purchased on Dec 28, 2003. Vehicle was not using anit-lock brakes. Vehicle was using Cruise Control.Vehicle had 6 cylinders. Chrysler PACIFICA 2004 Drive type:AWD. Fuel System:Fuel injection. Fuel type: gas. Chrysler PACIFICA 2004 Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve) Transmission Type: AUTO.

Chrysler Pt Cruiser 2001
Daimlerchrysler Corporation
Safety incident date:
Mar 24, 2006
Location:
San Leandro, CA

2 years into my ownership, my car began having failures, my egr valve had to be replaced 3 times, the "brain" in the car was replaced, the battery was replaced,the fog lights started going on and staying on, the car broke down on the highway and overheated, thermostat had to be replaced, pipe carrying circulating coolant rusted completely out, o ring was replaced,manual transmission began being difficult to shift, fluid leaks,low fluid, plug is recommended to be replaced.*jb

Mileage was 85000 miles. Vehicle Identification Number (VIN):3C8FY4BB81T. Original Owner. Vehicle was purchased on Mar 03, 2001. Vehicle was not using anit-lock brakes. Vehicle was using Cruise Control.Vehicle had 4 cylinders. Chrysler PT CRUISER 2001 Drive type:FWD. Fuel System:Fuel injection. Fuel type: gas. Chrysler PT CRUISER 2001 Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve) Transmission Type: MAN . Dealer's name: Hayward Auto . Dealer's telephone number: 510 278-8600 . Dealer's city: Hayward . Dealer's state code: CA.

Chrysler Town And Country 2004
Daimlerchrysler Corporation
Safety incident date:
May 15, 2006
Location:
Brunswick, OH

dt*: the contact stated while driving 20 mph or less, the check engine light illuminated followed by hesitation of the engine. the vehicle was inspected by a dealer. a diagnostic test was performed and the dealer determined a spark plug needed to be replaced. afterwards, the problem returned, and the vehicle was taken to another dealer for replacement of all spark plugs, spark plug boots, and the ignition. the problem persisted, and the vehicle was taken for an additional diagnostic test and it was determined there was a faulty egr valve. other people to whom the contact spoke to had similar problems with the chrysler 3.3 litre engine. the contact has to pay $100.00 deductible every time that vehicle is taken to the dealer. the contact feels there should be a recall. updated on 06/01/2006. *ak *ts

Mileage was 58200 miles. Vehicle Identification Number (VIN):2C4GP44R04R. Original Owner. Vehicle was purchased on Mar 06, 2004. Vehicle was using anit-lock brakes.Vehicle was using Cruise Control.Vehicle had 6 cylinders. Chrysler TOWN AND COUNTRY 2004 Drive type:FWD. Fuel System:Fuel injection. Fuel type: gas. Chrysler TOWN AND COUNTRY 2004 Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve) Transmission Type: AUTO. Vehicle Speed: 20 mph. Dealer's name: Brunswick Auto Mart . Dealer's telephone number: 330-273-3300 . Dealer's city: Brunswick . Dealer's state code: OH. Dealer's zipcode: 44212 .

Chrysler Pt Cruiser Convertible 2005
Daimlerchrysler Corporation
Safety incident date:
June 21, 2007
Location:
Canyon Country, CA

my pt cruiser since i have owned it burns oil prior to 3,000 miles due oil change. chrysler claims "it is normal for this car to burn 1 quart of oil every 1,000. miles. they refuse to check in between oil changes that this is in fact happening. *tr

Vehicle Identification Number (VIN):3C3EY45X35T. Original Owner. Vehicle was purchased on Oct 31, 2004. Vehicle was not using anit-lock brakes. Vehicle was not using Cruise Control. Vehicle had 4 cylinders. Chrysler PT CRUISER CONVERTIBLE 2005 Drive type:FWD. Fuel type: gas. Chrysler PT CRUISER CONVERTIBLE 2005 Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve) Transmission Type: MAN . Dealer's name: Power Chrysler . Dealer's city: Valencia . Dealer's state code: CA. Dealer's zipcode: 91351 .

Chrysler Town And Country 2005
Daimlerchrysler Corporation
Safety incident date:
Dec 03, 2007
Location:
Galesburg, IL

2005 chrysler town and country with multiple problems. consumer states seat belt light does not illuminate when there are no seat belts on. passenger air bag light says off when the wheel chair is in the front passenger position. *kb the consumer stated the vehicle was modified to accommodate a wheelchair. the steering gear and egr valve were replaced. *jb

Vehicle Identification Number (VIN):2C4GP54L65R. Vehicle was purchased on Apr 09, 2007. Vehicle was not using anit-lock brakes. Vehicle was not using Cruise Control. Vehicle had 6 cylinders.

Chrysler Pacifica 2004
Chrysler Llc
Safety incident date:
Jan 01, 1901
Location:
Delmar, NY

2004 chrysler pacifica has a problem with the motor mounts. consumer states the mounts have been on back order since dec. 2008. *nj the consumer stated a noise was heard when gong over bumps in the road. the anti-lock wheel sensor was bad, the tire light illuminated, the lower control arms and front sway bar were replaced. the motor mounts were leaking oil. the instrument cluster was not working and the egr valve was replaced. *jb

Vehicle Identification Number (VIN):2C8GM68414R. Original Owner. Vehicle was using anit-lock brakes.Vehicle was not using Cruise Control. Vehicle had 6 cylinders. Fuel System:Fuel injection. Fuel type: gas. Dealer's name: Armory Garage . Dealer's telephone number: 518-641-7777 . Dealer's city: Albany . Dealer's state code: NY. Dealer's zipcode: 12205 .

Chrysler Town And Country 2007
Chrysler Group Llc
Safety incident date:
July 07, 2010
Location:
Baltic, CT

2007 chrysler town and country. consumer writes regarding vehicle repairs and warranty *tgw the consumer stated while backing out of the driveway, the axle broke in half and fell to the ground. also, on a separate occasion, the check engine light illuminated and the vehicle stalled. a diagnostic check revealed the egr failed and egr gasket failed. *jb

Mileage was 40578 miles. Vehicle Identification Number (VIN):1A4GJ45R37B. Vehicle was not using anit-lock brakes. Vehicle was not using Cruise Control. Vehicle had 6 cylinders. Fuel System:Fuel injection. Fuel type: gas. Chrysler TOWN AND COUNTRY 2007 Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve) Transmission Type: AUTO. Dealer's name: Austin's Garage Inc . Dealer's telephone number: 860-822-8933 . Dealer's zipcode: 06360 .

Chrysler Town And Country 2008
Chrysler Group Llc
Safety incident date:
Apr 02, 2012
Location:
Menominee, MI

2008 chrysler town and country. consumer states writes in regards to safety recall lo1 *tgw according to the repair invoice, the check engine light was on. the dealer replaced the egr valve. *jb

Vehicle Identification Number (VIN):2A8HR54P78R. Vehicle was not using anit-lock brakes. Vehicle was not using Cruise Control. Vehicle had 6 cylinders. Chrysler TOWN AND COUNTRY 2008 Drive type:FWD. Fuel System:Fuel injection. Fuel type: gas. Dealer's name: Riverside Auto Sales . Dealer's telephone number: 715-735-3361 . Dealer's zipcode: 54143 .

Chrysler Town And Country 2010
Chrysler Group Llc
Safety incident date:
Feb 13, 2013
Location:
Boyne, MI

tl* the contact owns a 2010 chrysler town and country. the contact stated that while attempting to start the vehicle, a loud abnormal clicking sound emitted from the engine. the problem persisted. the egr valve was replaced. the manufacturer was not notified of the failure. the approximate failure mileage was 60,000. updated 10/10/14*cn the consumer stated the vehicle stalled. updated 11/18/14

0 person(s) were injured. 0 person(s) died.Mileage was 60000 miles. Vehicle Identification Number (VIN):2A4RR5DXXAR. Vehicle was not using anit-lock brakes. Vehicle was not using Cruise Control. Vehicle had 6 cylinders. Chrysler TOWN AND COUNTRY 2010 Drive type:FWD. Fuel System:Fuel injection. Fuel type: gas. Dealer's name: Bill Bryan Chrysler . Dealer's telephone number: 352-787-2223 . Dealer's city: Fruitland Park . Dealer's state code: FL. Dealer's zipcode: 34731 .


Common Chrysler Problems

View Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve) Safety Reports

Electrical System (2733 Reviews)

Power Train:automatic Transmission (1600 Reviews)

Engine (1314 Reviews)

Engine And Engine Cooling (1217 Reviews)

Air Bags (1181 Reviews)

Engine And Engine Cooling:engine (1144 Reviews)

Steering (1101 Reviews)

Power Train (1019 Reviews)

Service Brakes, Hydraulic:antilock (1011 Reviews)

Vehicle Speed Control (958 Reviews)

Fuel System, Gasoline (799 Reviews)

Air Bags:frontal (712 Reviews)

Service Brakes, Hydraulic (704 Reviews)

Suspension (665 Reviews)

Structure (620 Reviews)

Exterior Lighting (571 Reviews)

Unknown Or Other (515 Reviews)

Engine And Engine Cooling:engine:gasoline (477 Reviews)

Fuel/propulsion System (459 Reviews)

Structure:body (438 Reviews)


footer